US Aviation Body, Boeing Say Fuel Switch Locks Safe Amid Air India Crash Probe: Report
A 2018 FAA alert advised, but didn't mandate, airlines to inspect locking mechanisms on fuel cutoff switches across several Boeing models, the report said.
As investigations continue into the fatal crash of an Air India Boeing 787-8 aircraft last month, the US Federal Aviation Administration (FAA) and Boeing have privately reassured global aviation authorities and operators that the aircraft's fuel switch locking mechanisms are safe, according to a document reviewed by Reuters and four sources familiar with the matter.
The FAA issued a Continued Airworthiness Notification to the International Community (CANIC) on July 11, stating that it did not consider the design of the fuel control switches — including the locking features — to constitute 'an unsafe condition" that would require formal directives for any Boeing models, including the 787. Reuters reviewed the notification, which was sent to civil aviation authorities globally.
'Although the fuel control switch design, including the locking feature, is similar on various Boeing aeroplane models, the FAA does not consider this issue to be an unsafe condition," the notification said.
When asked for comment, the FAA declined to elaborate beyond the contents of the notification, Reuters reported.
Boeing, in parallel, communicated with airline operators through a Multi-Operator Message (MOM), referencing the FAA's position and stating that no immediate action was recommended. Two sources told Reuters that Boeing, too, is not planning any corrective changes at this point. The aircraft manufacturer referred further queries to the FAA.
The assurances follow a preliminary report by India's Aircraft Accident Investigation Bureau (AAIB) into the crash, which killed all 260 people on board. The report highlighted that the aircraft's engine fuel cutoff switches flipped from 'run" to 'cutoff" almost simultaneously during takeoff — a key event that investigators are scrutinising.
The report also cited a 2018 FAA Safety Alert for Operators (SAFO) that had advised — but not mandated — airlines to inspect the locking mechanism on fuel cutoff switches for several Boeing models, including the 787. Air India stated that it had not conducted those inspections, as they were not compulsory.
However, maintenance logs showed the aircraft's throttle control module, which houses the switches, had been replaced in 2019 and again in 2023.
The AAIB concluded that all applicable airworthiness directives and service bulletins had been complied with before the crash.
Meanwhile, ALPA India, the body representing Indian pilots under the International Federation of Air Line Pilots' Associations, has pushed back against what it sees as premature conclusions about pilot error. In a statement to Reuters, ALPA India President Sam Thomas urged authorities to allow the pilots' union to observe the probe and called for a 'fair, fact-based inquiry."
'The pilot's body must now be made part of the probe, at least as observers," Thomas told Reuters, pointing to the same 2018 advisory as a sign of potential equipment malfunction.
The cockpit voice recorder captured one pilot asking the other why he had cut the fuel supply during takeoff, to which the latter reportedly responded that he had not, Reuters reported. Investigators have yet to determine how the switches could have been flipped during the flight.
Two US-based aviation safety experts echoed ALPA India's call for transparency, though they told Reuters they did not see any overt bias in the AAIB's preliminary findings. John Cox, a former U.S. ALPA representative, described the report as 'objective and fair."
(With inputs from Reuters)
view comments
First Published:
July 14, 2025, 08:52 IST
Disclaimer: Comments reflect users' views, not News18's. Please keep discussions respectful and constructive. Abusive, defamatory, or illegal comments will be removed. News18 may disable any comment at its discretion. By posting, you agree to our Terms of Use and Privacy Policy.
Try Our AI Features
Explore what Daily8 AI can do for you:
Comments
No comments yet...
Related Articles
Hindustan Times
13 minutes ago
- Hindustan Times
Boeing defense union strikes for first time in almost 30 years
Workers at Boeing Co.'s St. Louis-area defense factories are striking for the first time in almost three decades after union members rejected the company's modified contract offer. A worker pickets outside the Boeing Defense, Space & Security facility in Berkeley, Missouri, US, on Monday, Aug. 4, 2025.(Bloomberg) About 3,200 machinists walked off the job around midnight after members voted down a deal that would have raised wages by 20% and boosted retirement contributions. The union last went on strike in 1996, with the stoppage lasting 99 days. 'IAM District 837 members have spoken loud and clear, they deserve a contract that reflects their skill, dedication, and the critical role they play in our nation's defense,' Tom Boelling, the union local's top official, said in a statement ahead of the deadline. The labor action will amplify financial pressure on Boeing's defense and space division, which generates almost a third of the company's revenue. At the same time, the operation that's now gone on strike is far smaller than the civil aircraft business that was severely affected late last year by a walkout, which brought manufacturing in the Seattle area to a standstill for weeks and contributed to Boeing selling equity worth almost $24 billion. 'We are prepared for a strike and have fully implemented our contingency plan to ensure our non-striking workforce can continue supporting our customers,' Dan Gillian, a Boeing vice president and senior St. Louis site executive, said in a statement. Union members build fighter aircraft such as the F-15, the T-7 training jet, missiles and munitions. They also manufacture components for Boeing's 777X commercial jets. In March, Boeing won a contract to design and build the US's next-generation stealth fighter jet, beating out rival Lockheed Martin Corp. for the multibillion dollar program dubbed the F-47. Boeing's defense business was profitable for a second consecutive quarter, the company said last month, as it avoided charges that long dogged the business. The company also managed to improve the performance of fixed-price development programs responsible for the worst of previous overruns. There's been a recent groundswell of activism at aerospace manufacturers, with unions gaining leverage amid shortages of highly skilled mechanics. Machinists walked off the job for three weeks at Pratt & Whitney this year, contributing to engine shortages at planemaker Airbus SE. Boeing's commercial factories were shut down by striking workers for two months in late 2024. Boeing Chief Executive Officer Kelly Ortberg downplayed the potential fallout from a strike during the company's July 29 earnings call. 'The order of magnitude of this is much, much less than what we saw last fall,' Ortberg said, noting that the St. Louis union is about 1/10 the size of the Seattle-based union that struck last fall. 'I wouldn't worry too much about the implications of the strike. We'll manage our way through that.' Boeing had crafted its latest offer to address concerns raised by members of International Association of Machinists and Aerospace Workers Local 837 after they rejected its initial proposal last week, Gillian told reporters on July 31. Boeing's proposal to district members would see average wages increase to $102,600 from $75,000 for IAM 837 members. Boeing also eliminated a controversial schedule proposal and revised its 401(k) terms so that workers get the full contribution increase upfront instead of spread over three years. Boeing cautioned that it would withdraw a $5,000 signing bonus and wouldn't offer it again to workers if the contract wasn't ratified on Sunday.
Mint
an hour ago
- Mint
Oil falls as OPEC output hike adds to oversupply concerns
By Shariq Khan and Enes Tunagur NEW YORK/LONDON (Reuters) -Oil prices fell to their lowest in a week on Monday after OPEC agreed to another large output increase in September, adding to oversupply concerns after U.S. data showed lacklustre fuel demand in the top consuming nation. Brent crude futures fell 43 cents, or 0.6%, to $69.24 a barrel by 11:39 a.m. ET (1539 GMT), while U.S. West Texas Intermediate crude declined by 48 cents, or 0.7%, to $66.85 a barrel. Both contracts were down more than 2% earlier in the session and hit the lowest in a week, after declining close to 3% on Friday. The Organization of the Petroleum Exporting Countries and its allies, together known as OPEC , agreed on Sunday to raise oil production by 547,000 barrels per day (bpd) for September. The latest in a series of accelerated output increases aimed at capturing market share was in line with market expectations and marks a full and early reversal of the group's largest tranche of output cuts, amounting to about 2.5 million bpd, or about 2.4% of global demand. While the group cited healthy market fundamentals to back its decision, data released by the U.S. government last week showed the weakest gasoline demand in May, the start of the country's summer driving season, since the COVID-19 pandemic of 2020. The data also showed U.S. oil production at a monthly record in May, adding to global oversupply concerns. Oil traders are now hedging for the possibility of further supply increases from OPEC , with potential discussions to unwind a further 1.65 million bpd of cuts at the group's next meeting on September 7 adding pressure to oil prices. "OPEC retains a substantial amount of spare production capacity, and markets are now watching closely to see whether the group will tap into it," StoneX analyst Alex Hodes said. "So far, there are no clear signals that OPEC intends to deploy this additional capacity, but the possibility remains on the table," he added. Analysts at Goldman Sachs expect that the actual increase in supply from the eight OPEC countries that have raised output since March will be 1.7 million bpd because other members have cut output after overproducing. Investors also continued to digest the impact of the latest U.S. tariffs on exports from dozens of trading partners and remain wary of further U.S. sanctions on Russia. U.S. President Donald Trump has threatened to impose 100% secondary tariffs on Russian crude buyers as he seeks to pressure Moscow into halting its war in Ukraine. Trump on Monday said he will substantially raise tariffs on India over its purchases of Russian oil, after two Indian government sources told Reuters over the weekend that the country will keep buying oil from Moscow despite Trump's threats. That helped limit oil's losses. About 1.7 million bpd of crude supply will be at risk if Indian refiners stop buying Russian oil, ING analysts said in a note.
Mint
an hour ago
- Mint
Oil falls as OPEC output hike adds to oversupply concerns
By Shariq Khan and Enes Tunagur NEW YORK/LONDON (Reuters) -Oil prices fell to their lowest in a week on Monday after OPEC agreed to another large output increase in September, adding to oversupply concerns after U.S. data showed lacklustre fuel demand in the top consuming nation. Brent crude futures fell 43 cents, or 0.6%, to $69.24 a barrel by 11:39 a.m. ET (1539 GMT), while U.S. West Texas Intermediate crude declined by 48 cents, or 0.7%, to $66.85 a barrel. Both contracts were down more than 2% earlier in the session and hit the lowest in a week, after declining close to 3% on Friday. The Organization of the Petroleum Exporting Countries and its allies, together known as OPEC , agreed on Sunday to raise oil production by 547,000 barrels per day (bpd) for September. The latest in a series of accelerated output increases aimed at capturing market share was in line with market expectations and marks a full and early reversal of the group's largest tranche of output cuts, amounting to about 2.5 million bpd, or about 2.4% of global demand. While the group cited healthy market fundamentals to back its decision, data released by the U.S. government last week showed the weakest gasoline demand in May, the start of the country's summer driving season, since the COVID-19 pandemic of 2020. The data also showed U.S. oil production at a monthly record in May, adding to global oversupply concerns. Oil traders are now hedging for the possibility of further supply increases from OPEC , with potential discussions to unwind a further 1.65 million bpd of cuts at the group's next meeting on September 7 adding pressure to oil prices. "OPEC retains a substantial amount of spare production capacity, and markets are now watching closely to see whether the group will tap into it," StoneX analyst Alex Hodes said. "So far, there are no clear signals that OPEC intends to deploy this additional capacity, but the possibility remains on the table," he added. Analysts at Goldman Sachs expect that the actual increase in supply from the eight OPEC countries that have raised output since March will be 1.7 million bpd because other members have cut output after overproducing. Investors also continued to digest the impact of the latest U.S. tariffs on exports from dozens of trading partners and remain wary of further U.S. sanctions on Russia. U.S. President Donald Trump has threatened to impose 100% secondary tariffs on Russian crude buyers as he seeks to pressure Moscow into halting its war in Ukraine. Trump on Monday said he will substantially raise tariffs on India over its purchases of Russian oil, after two Indian government sources told Reuters over the weekend that the country will keep buying oil from Moscow despite Trump's threats. That helped limit oil's losses. About 1.7 million bpd of crude supply will be at risk if Indian refiners stop buying Russian oil, ING analysts said in a note. (Reporting by Shariq Khan, Enes Tunagur and Florence TanEditing by Emelia Sithole-Matarise, David Goodman and Susan Fenton)
