
Air India flight crash: Not easy to ‘accidentally' cut off fuel switches, expert says
The London-bound Boeing 787 Dreamliner crashed into a medical college shortly after taking off from Ahmedabad Airport on June 12, killing 241 people on board.
Another 19 other people also died and 67 were seriously injured.
A preliminary report from India's Aircraft Accident Investigation Bureau, published on Friday, said both of the plane's fuel switches moved to the 'cut-off' position 'immediately' after take-off, stopping fuel supply to the engine.
'In the cockpit voice recording, one of the pilots is heard asking the other why did he cut-off. The other pilot responded that he did not do so,' the report reads.
The switches were then returned to their normal inflight position, which triggered an automatic engine relight and a thrust recovery procedure.
While the engines started to recover, one of the pilots transmitted 'mayday, mayday, mayday', before the plane was seen by air traffic control to crash outside the airport.
The fuel switches are used at the end of every flight and in emergency scenarios such as a fire, director of aerospace and aviation at Cranfield University, Professor Graham Braithwaite said.
They are designed so they cannot easily be 'accidentally' turned off and pilots would generally run through a checklist before doing so, he said.
'For obvious reasons, the two switches are a distance apart, so not a huge distance, but enough that you couldn't accidentally switch two when you're trying to switch one.
'So it's not like the lights in your house, where they're right next to each other, so there is some space between them.
'They're in that centre console, so that's in between the two pilots, so they can each reach them with the same ease.'
Professor Braithwaite said that if the switch had been moved by a person, that would have been a 'very unusual thing to do' at below 1,000 feet.
'It's not the point of flight where you try and call for your coffee, it's a period of flight where your focus is very, very clear, and that first 1,000 feet, it's about keeping the airplane climbing and that's not about clicking switches.'
He added: 'I could see why a nervous flyer would be nervous at the thought that it's possible to shut both engines down at a critical stage in flight, but for whatever reason, and that there are a number of things that are in place to stop it from accidentally happening.'
The aircraft was about 11 years old, the fuel switches had been changed two years ago, and the crash was a 'really, really unusual event', Professor Braithwaite said.
Of the next stage of the investigation, he said: 'If somebody did wilfully move a switch, then was it on the one hand a wilful active sabotage, in which case the investigation changes considerably, because this safety investigation that published the report yesterday will not be leading on that, that would be a police investigation.
'So that would change at that point, but if it wasn't clear that it was that wilful action, you'd be looking at, well, what kind of mistake might somebody have made?'
Of his general thoughts on the preliminary report, he said the authors have been 'very careful in their wording' to demonstrate they remain 'open minded' about what could have happened.
A lawyer advising some of the families affected by the crash said the findings were 'deeply concerning'.
Demetrius Danas, an aviation lawyer at Irwin Mitchell, said: 'Our thoughts and sympathies remain with those who've lost loved ones in such devastating circumstances.
'The findings of the initial report are deeply concerning and certainly merit further scrutiny to establish the full facts around how this tragedy happened.
'We're continuing to speak with and advise families who've been affected by the Air India crash. Understandably, all they want is to be provided with answers.'
The only surviving passenger on the plane was Briton Vishwash Kumar Ramesh, who previously told The Sun it was a 'miracle' he was alive but felt 'terrible' he could not save his brother Ajay.
Some 169 Indian passengers and 52 British nationals were killed, making it one of the deadliest plane crashes in terms of the number of British fatalities.
If the final investigation takes more than a year to complete, an interim report would be issued on the anniversary of the crash, Professor Braithwaite said, adding that interim recommendations could be made at any time.
The preliminary report says that all crew members had been breathalised on their arrival at Ahmedabad airport, which found they were 'fit to operate the flight'.
No significant bird activity was spotted near the flight path and the aircraft started to lose altitude before crossing the airport perimeter wall.
Both engines were retrieved from the wreckage and quarantined at a hangar in the nearby airport.
Investigators have identified 'components of interest for further examinations', the report says.
Fuel samples taken from tanks used to refuel the aircraft were 'satisfactory'.
Statements have been taken from Mr Ramesh and witnesses by investigators, who will also be looking at the post-mortem examination reports of the crew and the passengers.
This is being done 'to corroborate aeromedical findings with the engineering appreciation', the report adds.
An Air India spokesman said: 'Air India stands in solidarity with the families and those affected by the AI171 accident. We continue to mourn the loss and are fully committed to providing support during this difficult time.'
The spokesman added: 'Air India is working closely with stakeholders, including regulators.
'We continue to fully co-operate with the Aircraft Accident Investigation Bureau (AAIB) and other authorities as their investigation progresses.
'Given the active nature of the investigation, we are unable to comment on specific details and refer all such inquiries to the AAIB.'
Hashtags

Try Our AI Features
Explore what Daily8 AI can do for you:
Comments
No comments yet...
Related Articles


Sky News
2 hours ago
- Sky News
Air India plane suffered 'no mechanical fault' before crash, chief executive says in memo
A preliminary report into last month's fatal Air India crash found there was no mechanical or maintenance faults on board the plane, the airline's chief executive has said in a memo to staff. Chief executive Campbell Wilson said in the note, seen by the news agency Reuters, that the report had also found that all required maintenance on the aircraft had been carried out. He said the investigation into the crash, which saw all but one of the 242 passengers on board and 19 others on the ground killed when the Boeing aircraft plummeted shortly after take-off on 12 June, was far from over. The plane was on its way to London when it crashed during take-off from India's Ahmedabad Airport. Mr Wilson said it was unwise to jump to any premature conclusions, after the preliminary report found fuel to the engines of the plane appeared to have cut off shortly after take-off. According to the report by India's Aircraft Accident Investigation Bureau (AAIB), switches in the Boeing 787 Dreamliner's cockpit that controlled fuel moved to a "CUTOFF" position. There was then confusion in the cockpit. In the voice recording, one of the pilots is heard asking the other why he "cut off". The other pilot responds that he did not do so. 0:58 Mr Wilson's memo said: "The release of the preliminary report marked the point at which we, along with the world, began receiving additional details about what took place. "Unsurprisingly, it provided both greater clarity and opened additional questions." It added: "The preliminary report identified no cause nor made any recommendations, so I urge everyone to avoid drawing premature conclusions as the investigation is far from over." ALPA India, which represents Indian pilots at the Montreal-based International Federation of Air Line Pilots' Associations, rejected the presumption of pilot error in the Ahmedabad crash and called for a "fair, fact-based inquiry". "The pilots' body must now be made part of the probe, at least as observers," ALPA India president Sam Thomas told Reuters on Sunday. Both pilots were experienced, with around 19,000 flying hours between them, including more than 9,000 on the 787. The preliminary report, released on Saturday, suggested no immediate action for Boeing or GE, whose engines were fitted to the aircraft. It comes as the US Federal Aviation Administration and Boeing have privately issued notifications that the fuel switch locks on Boeing planes are safe, a document seen by Reuters showed, and four sources with knowledge of the matter said.


The Sun
2 hours ago
- The Sun
All Indian aircraft ordered to check vital fuel switches behind jet crash – amid fears disaster was pilot suicide
AIRLINES in India were today ordered to carry out urgent safety checks as the row over the crash which killed 260 people intensified. In 2018 regulators warned that a safety mechanism on fuel switches could disengage, increasing the chance of accidentally cutting off the engines. 9 9 9 9 Air India didn't check its planes at the time because the notice was not mandatory. But India's Directorate General of Civil Aviation (DGCA) has now ordered airlines to carry out checks by next Monday. It comes as yet another pilot body slammed the preliminary report into the crash for turning the focus onto the captain and his first officer. Although the 15-page report did not rule out a mechanical cause, experts said it pointed towards a deliberate human act leading to fears of pilot suicide or mass homicide. The Indian Commercial Pilots Association (ICPA) said it was "deeply disturbed by speculative narratives... particularly the reckless and unfounded insinuation of pilot suicide". The association said: "There is absolutely no basis for such a claim at this stage. It is deeply insensitive to the individuals and families involved. "To casually suggest pilot suicide without verified evidence is a gross violation of ethical reporting and a disservice to the dignity of the profession.' Flight AI 171 crashed on June 12 with the loss of 260 lives after first one fuel switch and then the other was turned off three seconds into the flight. The black box recorded one of the pilots asking the other: 'Why did you cut off?' to which the second replied: 'I did not do so.' The switches were turned back on but only one engine re-started and not in time to prevent the crash. Air India victims' families slam 'cover-up' probe as questions remain over possible engine switch confusion The report highlighted the 2018 US Federal Aviation Administration advice warning operators about the potential disengagement of the switches' locking mechanism, designed to prevent accidental operation. It applied to various Boeing models, including the 787 which was the plane that crashed last month. The notice was advisory, not mandatory, so Air India did not carry out any checks but the firm and all other airlines have now been ordered to do so. The DGCA said today: 'All airline operators of the affected aircraft are hereby advised to complete the inspection required no later than 21st July, 2025. 'Strict adherence to the timeline is essential to ensure continued airworthiness and safety of operations.' It comes as fears grow that the doomed flight was a pilot suicide. 9 9 And an aviation expert claimed this week that there was a vanishingly small chance the fuel was cut by accident. Ex-pilot Terry Tozer told The Sun why it was extremely likely that the fuel switches were cut off intentionally. The claims came after the preliminary report which revealed the final moments inside the cockpit was released on Saturday. Air India's CEO was also revealed to have backed the doomed fight's pilots in a leaked memo, Reuters reported. Key findings of the report: Dual engine shutdown - fuel cutoff switches moved from 'RUN' to 'CUTOFF' Confusion between pilots - cockpit audio confirms one pilot asked 'why did you cutoff', the other replied 'I didn't' RAT deployed - as seen in CCTV footage before the crash Engine relight attempted - fuel switches were found returned to the "RUN" at crash site 32 seconds - the time the aircraft was airborne before it crashed Thrust levers mismatch - Thrust levers found at idle but black box data shows takeoff thrust was still engaged Fuel test pass - fuel was clean without any contamination Normal take-off set-up - Flaps and landing gear correctly configured No bird activity - clear skies, good visibility, light winds Pilot credentials clear - both medically fit and rested No sabotage detected - although FAA alerted over a known fuel switch vulnerability not checked by Air India Aircraft loading - the flight was within weight and balance limits Airline head Campbell Wilson said the probe into the horrific crash was far from over and warned it would be unwise to jump to any conclusions. He said in the memo: "The release of the preliminary report marked the point at which we, along with the world, began receiving additional details about what took place. "Unsurprisingly, it provided both greater clarity and opened additional questions." Wilson added: "The preliminary report identified no cause nor made any recommendations, so I urge everyone to avoid drawing premature conclusions as the investigation is far from over." 9 9 9


Daily Mirror
3 hours ago
- Daily Mirror
Air India crash mystery in full - medical record probe to chilling fuel theory
A preliminary report into the tragic Air India 171 crash that killed 260 people has sparked fury from grieving families and pilots alike, as it raises more questions than it does answers Families grieving the victims of the Air India plane crash have been left with more questions than answers after the official investigation into the disaster sparked a furious backlash. The preliminary report from India's Aircraft Accident Investigation Bureau, published on Friday, found that both fuel cutoff switches were flipped shortly after takeoff, shutting down the jet's engines. The London-bound Boeing 787 Dreamliner crashed into a crowded neighbourhood just minutes after it took off from Ahmedabad Airport on June 12, exploding into a fireball and killing 241 passengers, as well as 19 people on the ground. Only one man - British-Indian passenger Vishwashkumar Ramesh - survived the horror. While the report doesn't place blame the pilots for the disaster, aviation experts have pointed out that flipping the fuel cutoff switch has to be done manually. But unfounded speculation swirling online about a potential pilot suicide has sparked anger from one pilot association who insist the crew acted in line with their training should not be vilified. Those mourning the loss of loved ones killed in the crash last month have also slammed the report, stating they are still yet to find closure as the mystery around the exact cause continues to deepen. Now, as a probe is launched to look at one of the pilot's medical records and the CEO or Air India speaks out, we look at the unanswered questions in one of the worst aviation disasters in history. Chilling cockpit audio The preliminary report into the disaster revealed the chilling conversation had in the cockpit just moments before the plane crashed and erupted into flames. It sheds light on the moment one of the pilots realised that the fuel cutoff switches had been flipped, leaving the airline with no engine power. Revealing a panicked exchange, the report said: "In the cockpit voice recording, one of the pilots is heard asking the other why did he cutoff. The other pilot responded that he did not do so." "At about 08:09:05 UTC, one of the pilots transmitted "MAYDAY MAYDAY MAYDAY". The ATCO enquired about the call sign. ATCO did not get any response but observed the aircraft crashing outside the airport boundary and activated the emergency response." Fuel switch mystery Aviation experts have been quick to react to the report's findings that the fuel cutoff switches were seemingly flipped, with one claiming that the crew were "absolutely" the cause. Captain Mohan Ranganthan, one of India's key aviation experts, has suggested this potential cause could have been deliberate. Ranganthan, speaking to NDTV, said: "It has to be done manually, it cannot be done automatically or due to a power failure." These fuel switches have to be operated by pulling each lever upwards to unlock them before being flipped. These switches also have a protective guard bracket to protect them from accidental nudges or bumps. At the time the plane went down, one engine was regaining thrust while the other had relit but had not yet recovered power. Ranganthan added: "The fuel selectors they aren't the sliding type they are always in a slot. They are to pull them out or move them up or down, so the question of them moving inadvertently out of off position doesn't happen. It's a case of deliberate manual selection." He then claimed "nothing else" could have caused that possible explanation, adding: "It had to be deliberately done." Those investigating the crash say that the fuel switchers, which are level-locked, are designed to prevent accidental activation. "It would be almost impossible to pull both switches with a single movement of one hand, and this makes accidental deployment unlikely," an unnamed Canada-based air accidents investigator, told the BBC. Indian pilots slam 'disturbing' claims A group of Indian pilots have issued a furious statement in response to the report and the speculation it has sparked online. Defending the actions of the Air India crew, The Indian Commercial Pilots' Association (ICPA) say that staff "acted in line with their training and responsibilities under challenging conditions and the pilots shouldn't be vilified based on conjecture". "To casually suggest pilot suicide without verified evidence is a gross violation of ethical reporting and a disservice to the dignity of the profession," it fumed. The preliminary investigation does not offer any clarity on how the switches were moved before the crash, but social media users and some experts have been quick to speculate about the role of the pilots. "We are deeply disturbed by speculative narratives emerging in sections of the media and public discourse - particularly the reckless and unfounded insinuation of pilot suicide," the pilot association said. "Let us be unequivocally clear: there is absolutely no basis for such a claim at this stage, and invoking such a serious allegation based on incomplete or preliminary information is not only irresponsible - it is deeply insensitive to the individuals and families involved." Troubling warning six years before crash It has also been claimed that Air India was warned about wrongly installed fuel switches more than six years before the terrifying disaster. The preliminary report into the crash said in December 2018, the US air regulator Federal Aviation Administration (FAA) warned airlines that fuel switches had been installed in some Boeing 737s "with the locking feature disengaged". "If the locking feature is disengaged, the switch can be moved between the two positions without lifting the switch during transition, and the switch would be exposed to the potential of inadvertent operation," the FAA warned in a Special Airworthiness Information Bulletin. "Inadvertent operation of the switch could result in an unintended consequence, such as an in-flight engine shutdown." It recommended airlines inspect the switches, including "whether the fuel control switch can be moved between the two positions without lifting up the switch". Air India suggested such inspections were not carried out because the FAA's bulletin was "advisory and not mandatory", according to the report. The AAIB report says the fuel control switch design, including the locking feature, is similar on various Boeing airplane models including part number 4TL837-3D fitted in the 787-8 Dreamliner, the model that crashed in Ahmedabad. Switches are 'safe' As the preliminary report continues to rattle the industry, the US aviation regulator has been forced to step in and clarify that the fuel control switches in Boeing planes are safe. In response to Air India having been warned about wrongly installed switches six years ago, the US Federal Aviation Administration (FAA) noted that its own 2018 advisory "was based on reports that the fuel control switches were installed with the locking feature disengaged" - but it stated that it does not believe this makes the planes unsafe. "Although the fuel control switch design, including the locking feature, is similar on various Boeing airplane models, the FAA does not consider this issue to be an unsafe condition that would warrant an Airworthiness Directive on any Boeing airplane models, including the Model 787," said the authority, according to a note seen by the BBC. "The FAA will continue to share relevant information with foreign civil aviation authorities as appropriate." Medical records probe It emerged today that the medical records of one of the pilots of the doomed Air India plane are being examined after it has been claimed he suffered from poor mental health. Captain Sumeet Sabharwal was piloting the Boeing 787 Dreamliner when it crashed and aviation expert Captain Ranganathan has suggested that 'several' other pilots had allegedly claimed that he had suffered from poor mental health. Speaking to The Daily Telegraph, he claimed: "He had taken time off from flying in the last three to four years. He had taken medical leave for that." The publication said that while Air India declined to comment, an official working with their parent company, Tata Group, said that Captain Sabharwal had not taken any medical leave, with the preliminary report failing to obtain any significant findings. They added that within the last two years, both pilots onboard the flight had passed the Class I medical exam, which makes an evaluation of their psycho-physical capabilities. Air India CEO speaks out In a bid to ease growing concerns, the CEO of Air India Campbell Wilson has clarified that the preliminary report into the disaster found no mechanical or maintenance issues with the plane or its engines. An internal memo shows Mr Wilson explaining that the airline's whole 787 fleet had been inspected immediately after the crash and all planes were deemed fit for service, the Independent reports. He also stated that the pilots had passed their mandatory pre-flight breathalyser test and there were no observations regarding their medical status. Mr Wilson added that the investigation was "far from over". Grieving families desperate for truth Families of the Air India crash victims have slated the 'vague' initial investigation as they demand more clarity on the exact cause of the disaster. A relative of Dhir and Heer Baxi, who were travelling home to London after surprising their grandmother for her birthday when they died in the crash, said he was not satisfied by the report's findings. Ishan Baxi, the cousin of the two victims, said: "We're still hoping for a more transparent and honest investigation that doesn't shy away from addressing possible mechanical flaws or lapses in protocol to avoid future potential accidents. "I just hope the final report brings full clarity on what exactly failed and who's accountable. It shouldn't hide behind vague terms." And the loved ones grieving a family of three who died in the crash - Akeel Nanabawa, his wife, Hannaa Vorajee and their four-year-old daughter, Sara Nanabawa - issued a statement. "Moving forwards, we require honesty, transparency and an unwavering commitment to uncovering the full truth," they said. "We seek justice and answers, both of which are essential for us to find any sense of closure. We accept God's fate, but knowing what happened will help ease our hearts and allow us to begin the long journey of healing. 'Above all, we hope that by pursuing the truth, no other family will ever have to endure the shock, uncertainty, and profound sorrow that we have lived through this past month."